天然产物研究与开发 ›› 2022, Vol. 34 ›› Issue (6): 916-924.doi: 10.16333/j.1001-6880.2022.6.002

• 研究论文 • 上一篇    下一篇

不同干燥方法对栽培川贝母外观性状及内在质量的影响

李   巧1，种叶敏1，陈颖馨1，蔡晓洋1，李   敏1*，黄   勇2   

  1. 1成都中医药大学药学院 省部共建西南特色中药资源国家重点实验室，成都 611137；2四川绿林川贝母种植有限公司，凉山彝族自治州 615000
  • 出版日期:2022-06-28 发布日期:2022-06-29
  • 基金资助:
    四川省科技厅重点研发项目（2020YFS0303）；成都中医药大学“杏林学者”学科人才科研提升计划（CXTD2018016）

Appearance characters and internal quality of cultivated Fritillaria cirrhosa D.Don under different drying methods 

LI Qiao1,CHONG Ye-min1,CHEN Ying-xin1,CAI Xiao-yang1,LI Min1*,HUANG Yong2   

  1. 1State Key Laboratory of Southwestern Chinese Medicine Resources,College of Pharmacy,Chengdu University of Traditional Chinese Medicine,Chengdu 611137,China;2Sichuan Lvlin Fritillariae Cirrhosae Bulbus Planting Co.,Ltd.,Liangshan Yi Autonomous Prefecture 615000,China
  • Online:2022-06-28 Published:2022-06-29

PDF (PC)

50

摘要： 以栽培川贝母为研究对象，探究不同干燥方法对药材的外观性状及内在质量的影响，通过直观分析法并结合聚类分析、主成分分析进行综合评价。结果表明，传统晒干，外观性状较优，表面颜色偏白，断面粉性足，有效成分含量较高，但干燥耗时长，易受环境影响；热风干燥，干燥速率增加，耗时大幅度缩短，其中50~55 ℃温度干燥时与晒干法外观性状相似，除淀粉含量稍有降低外，浸出物、总生物碱含量均有所升高，而杀青处理与60 ℃处理，断面粉性减弱，角质化程度增加，并促进淀粉分解，淀粉含量相较于传统晒干法分别降低了33.6%、26.25%。冷冻干燥药材表面颜色类白色，内部质地松泡多孔，质地变轻，总生物碱、淀粉含量最高（分别为0.191%、70.37%）。综合分析可知，50~55 ℃热风干燥法优于传统晒干，可在栽培川贝母的产地加工中推广应用；冷冻干燥有效成分含量高，可用于药效成分提取。

关键词: 川贝母, 干燥方法, 外观性状, 内在质量, 聚类分析, 主成分分析

Abstract:

To investigate the effects of different drying methods on the appearance and internal quality of cultivated Fritillaria cirrhosa D.Don (CFC) by using intuitive analysis, cluster analysis (HCA) and principal component analysis (PCA). Results indicated that traditional sun-dried CFC has better appearance, white surface color, enough cross section mealiness, and high content of effective ingredients, but the drying rate was slow and vulnerable to the environment impact, while the drying rate of hot air drying was faster and the time was shortened. When the temperature was 50-55 ℃, the appearance of CFC was similar to that of the sun drying method, except for the content of total starch, the extract and total alkaloids all increased. However, in the fixation treatment and the 60 ℃ treatment, the cross section mealiness was weakened, degree of keratinization was increased, which also promoted the decomposition of starch, the starch content was reduced by 33.6% and 26.25% compared with the traditional drying method. The surface color of freeze-dried medicinal material was off-white, and the internal texture was loose and porous, and the texture became lighter, the content of total alkaloids and total starch was highest (0.191% and 70.37%, respectively). Comprehensive analysis showed that 50-55 ℃ hot air drying method are better than sun drying method, and can be popularized and applied in the processing of CFC in production place; in the freeze-drying method, the content of active ingredients is high, and it can be used for extraction of medicinal effective ingredients.

Key words: cultivated Fritillaria cirrhosa D.Don, drying methods, external appearance, internal quality, HCA, PCA

中图分类号:  R282.4

版权所有 © 《天然产物研究与开发》编辑部
地址：四川天府新区群贤南街289号　邮编：610299
电话：028-85210304　QQ群：342035423　Email：trcw@clas.ac.cn　
本系统由北京玛格泰克科技发展有限公司设计开发
总访问量：　今日访问：　在线人数：